NHTSA ID Number: 10202401
Manufacturer Communication Number: PIP5806D
Summary
This preliminary information bulletin instructs to technicians to check the trigger wheel for interfering with the timing chain, and adding a shim to the camshaft position sensor.
Condition:
Some customers may experience an intermittent extended crank or intermittent crank/no start, and may find DTC P0341 set. The vehicle will crank until it times out. The vehicle will start on the second attempt. The StopStart system is not affected by this condition.
Cause:
This may be due to a corrupt signal from camshaft position sensor to ECM.
Correction:
Remove the camshaft position sensor and use a borescope to inspect the camshaft trigger wheel for coming in contact with the timing chain. If the trigger wheel is coming into contact with the timing chain at any point, it will be necessary to replace the trigger wheel.
SEOCONTENT-START
Bulletin No.: PIP5806D Published date: N/A
Preliminary Information
PIP5806D Intermittent Extended Crank No Start And A Possible DTC P0341 Set
Models
Brand:
Chevrolet
GMC
Model:
Silverado Sierra
Model Years:
2020 – 2021
2020 – 2021
VIN:
from to
All All
All All
Engine:
LM2 LM2
All All
Transmissions:
Involved Region or Country:
Condition:
Cause:
North America
Some customers may experience an intermittent extended crank or intermittent crank/no start, and
may find DTC P0341 set. The vehicle will crank until it times out. The vehicle will start on the
second attempt. The StopStart system is not affected by this condition.
This may be due to a corrupt signal from camshaft position sensor to ECM.
Correction:
Remove the camshaft position sensor and use a borescope to inspect the camshaft trigger wheel for
coming
in contact with the timing chain. If the trigger wheel is coming into contact with the timing
chain at any point, it will be necessary to replace the trigger wheel.
It is necessary to roll the engine over by hand (up to two revolutions) to inspect each wheel
segment. See the picture below:
If the camshaft trigger wheel is not coming into contact with the timing chain at any point,
Install a .5mm shim to the camshaft position sensor, P/N 12565102.
Below are reference pictures of a good trigger wheel and chain:
1. Camshaft Position Reluctor Wheel
2. Camshaft Position Sensor
1. Camshaft Position Reluctor Wheel
Warranty Information
For vehicles repaired under the Bumper to Bumper and Emissions (E) coverage, use the following
labor operation. Reference the Applicable Warranties section of Investigate Vehicle History (IVH)
for coverage information.
Labor Operation Description
Labor Time
4088148 Camshaft Exciter Wheel Inspection and .5mm Camshaft Sensor shim installation
3.1 Hrs.
*This is a unique Labor Operation for Bulletin use only.
Version History
Version 5
Modified 05/24/2021 – Created on.
06/18/2021 – Modified to include checking for debris on the cam position sensor.
08/06/2021 – Modified to include checking for chain interference and adding
Camshaft position sensor shim and graphics.
08/13/2021 – Modified to update the labor code and description 09/21/2021 – Modified to remove the
SUVs
SEOCONTENT-END
12 Affected Products
Vehicles
| MAKE | MODEL | YEAR |
| CHEVROLET | SILVERADO 1500 | 2020-2021 |
| CHEVROLET | SILVERADO 2500 | 2020-2021 |
| CHEVROLET | SILVERADO 3500 | 2020-2021 |
| GMC | SIERRA 1500 | 2020-2021 |
| GMC | SIERRA 2500 | 2020-2021 |
| GMC | SIERRA 3500 | 2020-2021 |
1 Associated Document
Manufacturer Communications
Bulletin No.: PIP5806D
Published date: N/A
MC-10202401-9999.pdf 966.544KB
NHTSA ID Number: 10201311
Manufacturer Communication Number: PIP5806C
Summary
This preliminary information bulletin instructs to technicians to check the trigger wheel for interfering with the timing chain, and adding a shim to the camshaft position sensor.
1 Associated Document
Manufacturer Communications
Bulletin No.: PIP5806C
Published date: 08/16/2021
MC-10201311-9999.pdf 965.945KB
NHTSA ID Number: 10201306
Manufacturer Communication Number: PIP5806B
Summary
This preliminary information bulletin instructs to technicians to check the trigger wheel for interfering with the timing chain, and adding a shim to the camshaft position sensor.
1 Associated Document
Manufacturer Communications
Bulletin No.: PIP5806B
Published date: N/A
MC-10201306-9999.pdf 965.922KB
NHTSA ID Number: 10201289
Manufacturer Communication Number: PIP5806A
Summary
This preliminary information bulletin instructs to technicians to use the Picoscope or a make physical inspection to check for debris on the cam position sensor and to check for a bent target wheel on the camshaft.
1 Associated Document
Manufacturer Communications
Bulletin No.: PIP5806A
Published date: N/A
MC-10201289-9999.pdf 592.399KB
- Easily Maneuver Your View: Tired of struggling with hard-to-reach areas during inspections? This two-way articulating borescope effortlessly navigates tight and complex spaces with its flexible and maneuverable probe. Enjoy crystal-clear visual feedback that saves you both time and money. Whether for automotive maintenance or household inspections, this tool transforms your inspection journey, making the process faster and easier than ever.
- See Every Detail in Vivid Clarity: Experience the exceptional image quality of our 4.5-inch IPS LCD color screen, delivering sharp, high-resolution visuals. Whether you’re in bright sunlight or dim conditions, this display ensures you won’t miss a thing. Plus, with no app required, it's ready to go whenever you are!
- Master the Most Challenging Inspections: Equipped with a 5FT semi-rigid gooseneck cable, this borescope provides the ideal combination of flexibility and stability, allowing you to navigate tight, intricate spaces with ease. The cable retains its shape as you guide it, giving you precise control for thorough inspections. Designed for versatility, it adapts effortlessly to various environments, ensuring no detail goes unnoticed.
- Light Up the Darkest Corners: Equipped with built-in high-brightness LED lights on the camera probe, you’ll have the visibility you need even in the darkest environments. The adjustable illumination allows you to customize the brightness for every inspection, ensuring that no detail goes unnoticed in tight or confined spaces.
- Ergonomics Meet Efficiency: This borescope is thoughtfully designed for maximum comfort and usability. The centrally located articulating joystick allows for effortless one-handed operation with either hand. The photo button is conveniently positioned on the back, making it easy to capture images or videos during inspections. Lightweight and compact, this borescope ensures prolonged use without fatigue, perfect for on-the-go inspections.
- High Quality Display: The endoscope camera with light adopts a 4.3-inch IPS screen, which can provide a horizontal viewing angle of approximately 170°, and a highly sensitive chip that captures 1920x1080P HD images in real time. With colour flip and brightness shift functions, you get vivid, saturated and natural images from any angle. Note: This endoscope cannot take or store photos.
- Powerful Features Camera : Borescope delicate camera probe is equipped with 8 LED lights, which can adjust the brightness according to the button, so you don't need to worry about the dark environment. Inspection camera is also IP67 waterproof, so it is suitable for harsh and wet environments, and the optimal focusing distance (2cm-10cm) allows you to inspect the pipe wall carefully and clearly.
- Freely Bend 16.6FT Cable: The 1.29in short lens for narrow pipe inspection is half the length of conventional lenses, making it easier to manoeuvre at difficult angles. The 7.9mm camera probe and semi-rigid cable allow the snake camera to be bent at will, making it easy to reach a wide range of confined areas.
- Simple Operation: Just turn on the power and use it. There is no need to connect to WIFI with your smartphone or download any driver software. The ergonomic handle allows you to quickly pick up this lightweight sewer camera and use it comfortably without fatigue. You also do not need to worry about dirtying your expensive phone while working.
- Package Includes: Borescope Camera with Light*1, Hook*1, Magnet*1, Side Mirror*1, Type-c Data Cable*1, Manual*1. We provide 24-hour professional and attentive after-sales service. If you have any questions, please contact us.
- 1920P HD Resolution: Sewer camera with 7.9mm probe can inspect hard-to-reach places effortlessly. The 2.0MP HD endoscope can observe clear snapshot images (1920x1440 resolution) and high-quality video (1920x1440 resolution) at close range.
- Easy Connection: This borescope inspection camera can easily and quickly connect with IOS 9.0+ Android 7+ system devices through the interface. Search for 'SUP-ANESOK' in the APP store or scan the QR code to download the APP. With simple operations, you can view real-time images on the screen.
- Semi-Rigid Cable & Waterproof Probe: Snake Camera can bend freely and remain semi-rigid. The 16.4ft semi-rigid cable unrolls and rolls up quickly, which provides a good mix of flexibility and rigidity. The IP67 waterproof design allows the camera to operate underwater up to 3.28 feet for 1 hour.
- Wide Applications: Scope camera suitable for various scenes, such as inside the car or around the engine, inside the pipe inspection, or the house inspection mold, and wiring. The brightness-adjustable light enables you to obtain picture information even in dark environments.
- What You Get: Endoscope Camera *1, Android connector*1，Lightning Port*1，Type-C connector，16.4ft Semi-rigid Cable *1, Accessories: Magnet *1, Hook *1, Mirror *1, Protective Cap *1, Manual *1
- 【4.3-INCH LCD DISPLAY】HD Endoscope camera with a 4.3-inch color LCD screen that allows you to view high-definition images in real time. Easy to operate, you can use it immediately when it is powered on. No need to use your smartphone to connect to the WIFI and no need to download any driver software. So you do not need to worry about dirtying your expensive phone at work too. Note: The endoscope cannot take pictures and videos
- 【HIGH-QUALITY SNAKE CAMERA】8 adjustable LED lights to ensure a clear image even under dark conditions. The best observation distance: 1.5 in-5 in, making inspections easier. 16.5ft Semi-Rigid cable is both stiff and flexible to better meet your needs
- 【IP67 WATERPROOF】The borescope is rated IP67 waterproof for use in inclement weather and wet environments. The snake camera probe uses an aerospace connector that is water safe to use in pools, plumbing and the rain
- 【SAVE TIME AND MONEY】This is an excellent tool for car maintenance, home inspections, electrical installation, HVAC repairs, and home DIY. The 8mm endoscope camera can easily pass through the spark plug hole to inspect the combustion chamber of the engine. Alternatively, simply drill a hole in the wall to enter the inner wall for viewing, saving the trouble of damaging the wall
- 【WHAT'S IN THE BOX】1 inspection camera with light+1 user‘s manual+1 Type-C charging cable+1 hook+1 magnet+1 side mirror, Our worry-free 180 days warranty and friendly customer service. Warning: Please use a household charger device that meets safety requirements (5V 1A) for charging. Fast charging is not supported to prevent battery overheating
- 1920P HD Resolution: Specialized for plumbers and mechanics, this 1920×1440 endoscope captures sharper images than standard 1080P. The 7.9mm ultra-thin probe with 8 LEDs inspects pipes, HVAC, and tight spaces effortlessly—even in dark or damp conditions.
- Dual-Lens Flexibility: Switch Views Instantly – Dual-lens design toggles between front and side cameras with one click—no more awkward probe rotations. Perfect for inspecting pipe corners, wall wiring, and engine compartments from every angle.
- Semi-Rigid Cable Control: The 16.4FT semi-rigid cable bends smoothly but won't collapse, letting you navigate curves in drain pipes or HVAC ducts without losing control.
- Plug-and-Play Compatibility: Works with Any Device. Includes 3 detachable connectors: Type-C (for modern Android), Micro USB (older devices), and Lightning (iPhone). Simply scan the QR code to download our free app, then plug in to view real-time inspection footage directly on your smartphone screen.
- Package Include: Endoscope Camera *1, Micro-USB Port *1, Lightning Port *1, Type-C Port *1, 16.4ft Semi-rigid Cable *1, Magnet *1, Hook *1, Protective Cap *1, Instruction Manual *1
Last update on 2026-06-09 / Affiliate links / Images from Amazon Product Advertising API
This product presentation was made with AAWP plugin.