NHTSA ID Number: 10162151
Manufacturer Communication Number: PIT5692
Summary
This Preliminary Information communication provides information to the technician about how to diagnosis a battery draw that may be caused by a module back feeding voltage in the ignition relay circuits making the vehicle think it is still awake.
12 Affected Products
Vehicles
CADILLAC | ESCALADE ESV | 2017-2019 |
| CHEVROLET | SUBURBAN | 2017-2019 |
| CHEVROLET | TAHOE | 2017-2019 |
| GMC | YUKON DENALI | 2017-2019 |
SEOCONTENT-START
Bulletin No.: PIT5692
Published date: 06/24/2019
Preliminary Information
PIT5692 Diagnostic Tip For 12 Volt Battery Going Dead Overnight
Models Brand: Model: Model Years: VIN: Engine: Transmissions: from to
Cadillac Escalade Models 2017 – 2019 All All All All
Chevrolet Suburban 2017 – 2019 All All All All
Chevrolet Tahoe 2017 – 2019 All All All All
GMC Yukon Models 2017 – 2019 All All All All
Involved Region or Country North America
Condition
Some customers may experience one or all the following concerns:
1) Battery draw which typically is between 5 and 6 amps
2) Radio backlighting will stay on even after the ignition has been turned off and the key has been removed for several minutes
3) May Have current or history DTC: P2535
Cause This concern may be caused by unwanted voltage at the ignition fuses fed by the KR73 Ignition main relay in the X51L left Instrument Fuse box, with the Ignition off.
Correction:
If you experience any of the above concerns, check for voltage with a DVOM on all the fuses that are fed by the KR73 Ignition relay. These fuses are all on the same Run/Crank Ignition Buss Bar, in the Left I/P Fuse Block, and should not have any power with the ignition off. In some cases, there may only be 2 or 3 volts present, so a voltmeter must be used to check for voltage.
Example wiring diagram for the KR73 Ignition Main Relays and fuses is Document ID:
4501672.
If there is any voltage on the fuses with the ignition in the off position, remove fuses one at a time to isolate which module is causing the concern. Once you have located the effected module, Unplug the module and see if the back feed goes away. Once the module is isolated, replace as needed.
TAC has seen some issues in the field where the K29F front heated seat module or the K29R rear heated seat module may be causing the back feed concern.
Note: If you remove all the fuses fed by, the KR73 Ignition Main Relay and you cannot isolate the concern down to a single fuse, Inspect the backside of the X51L Fuse block in the instrument panel for corrosion. We have seen some cases where the front windshield or the OnStar Antenna has a water leak and causes corrosion on the backside of the fuse box.
Version History
Version 1
Modified 06/24/2019 – Created on.
SEOCONTENT-END
Bulletin No.: PIT5692
Published date: 06/24/2019
To View or Download this Document Click Here
- START DEAD BATTERIES — Instantly start dead batteries with 1000 amps of peak lithium power. Up to 20 starts per charge on engines up to 6.0L gas and 3.0L diesel.
- ULTRASAFE TECHNOLOGY — Engineered with patented spark-proof and reverse polarity protection for foolproof connections to any 12V vehicle - no sparks, no wrong connections.
- PORTABLE POWER BANK — Integrated power bank delivers emergency power to smartphones, tablets, and more. Recharges in 3 hours so it’s ready when it matters most.
- INTEGRATED LED FLASHLIGHT — Precision-engineered 100-lumen LED with 7 light modes, including SOS and strobe. Illuminate repairs, emergencies, or low-light environments.
- COMPACT YET POWERFUL — High-discharge lithium technology delivers exceptional starting performance in a compact 2.5 lb form factor - perfectly sized for glove boxes and emergency kits.
- [Emergency Save Dead Batteries] - Safely, stable and powerful, you can start a dead car battery in seconds, Gehopow jump starter with 6000A peak current for up to 10.0L gasoline or 8.0L diesel, suitable for 12v vehicles like car, suv, truck, van, motorcycle.
- [Waterproof Protection] - We hope users feel 100% safe when using our car battery jump starter. So we design the car jump starter with IP66 waterproof and dustproof, you can use it even in the rainy day.
- [Not Just a Car Tool] - This jump box is equipped with USB output port, can charge for phones, tablets, and other USB devices. Press 3 seconds can start the LED flashlight, with 3 light modes, including lighting, flash and SOS. The red sos light can be used as a emergency light.
- [Humanized and Advanced] - powerful and compact, the size of car jumper starter portable is 7.0*3.5*1.6 inches. Almost the size of a phone and with 1.7pound of weight is easy to carry. Featuring high-discharge lithium technology for safe, stable and efficient operation in any climate.
- [Package include] - A9 car jump starter*1, jumper cables*1, USB Type-C charging Cable*1, user maunel*1, storage case*1. Our after-sales customer service is available at any time. Please contact us for help.
- 【More Powerful Booster】This 5000-Amp peak lithium car battery jump starter battery pack can start a vehicle(10.0L Gas and 9.0L Diesel) in seconds, suitable for car, motorcycle, RV or tractor and so on. Operation Steps: 1.Insent the jumper cable into the booster, the traffic lights of the smart clip will flash alternately. 2.Connect the clamps to your car battery,the green light indicates a successful connection 3.Start your car engine 4.Remove the jumper cable.
- 【Portable Power Supply】With dual USB (5V/2A) output, this car starter battery pack can be used as a power bank to charge smartphone, laptop, and other USB devices.
- 【Multi-Protection】 Sharmeal Jump starter uses design of Integrated Battery and Intelligent Clamps, which is fully insulated and safe enough. 14 types of protection include spark-proof, reverse-polarity protection to protect you from failure problems such as short circuits or sparks.
- 【 800 Lumen Lighting】 Say goodbye to old bulky jump start battery pack! Sharmeal is more lightweight and portable. The battery starter utilizes 800-lumen lighting lasting 48h with 3 modes :Flash Light, Strobe Light, and SOS Light.
- 【 What You Get】Our Brand is specialized in vehicle emergency starter with 24 months warranty. Sharmeal jump pack (1* jump starter, 1* smart jumper cables, 1* type-C charging cable, 1* user manual, 1* portable carrying case). Regarding how to charge this product: to ensure charging performance, it is recommended to use the original charging cable provided with the product for charging.
- 4000A&88.8Wh Jump Starter - Megavolt24 is equipped with a powerful 88.8Wh battery. this car battery jump starter is well-suited for 12V vehicles like cars, trucks, boats, and larger vehicles. wolfpack effectively restores your vehicle's power in emergency situations, supporting both gasoline and diesel engines with a capacity of under 10 liters
- HD LCD Display - The LCD screen offers a transparent presentation of all the status indicators for the car jump starter portable supply. Easily observe the current condition of your emergency power source, enabling smooth access to all functionalities.
- 65W USB-C Quick Charging - Featuring 1 * 65W Type-C in/out port, 1 * QC3.0 USB-A port, and coming with a PD65W fast charger, our jump start battery pack source can be fully charged in just 1.3 hours. Equipped with two output ports, it efficiently charges various electronic devices such as phones, laptops, and iPads, making it a perfect choice for travel or camping.
- One-Touch Booster and LED Flashlight - This jump starter features a one-touch boost function for starting vehicles under low voltage. It also includes an LED flashlight with SOS, strobe, and high-beam modes, serving as an essential emergency tool.
- Withstands -4 to 140°F & High Security - the portable battery jumper starter operates reliably in extreme conditions. It has passed various safety tests, including UL, FCC, CE, and CA65. With an IP64 protection rating, it ensures resilience in harsh environments.For safe operation, do not reverse clamp polarity. Always follow the instructions before use.
This product presentation was made with AAWP plugin.