Product Emission Recall 17089 NOx Position 1 Sensor Replacement – 2014-2015 Chevrolet Cruze

NHTSA ID Number: 10143687

Manufacturer Communication Number: 17089 01

Summary

17089-01 – Product Emissions Recall. Revised. This bulletin has been revised to add the requirement for an SPS warranty claim code to accompany warranty transaction submission, and to add notes to the service procedure. Please discard all copies of bulletin 17089. General Motors has decided to conduct a Voluntary Emission Recall certain vehicles equipped with a 2.0L (RPO LUZ) diesel engine. On some vehicles, depending on driving habits, soot may build up on the engine?s NOx position 1 sensor and / or oxygen sensor, causing the vehicle Check Engine Indicator to illuminate. An earlier correction for this condition (Voluntary Emission Recall 15594) may, under certain driving conditions, inadvertently cause the vehicle Check Engine Indicator to illuminate.For vehicles that were not serviced under previous recall 15594, dealers are to replace the NOx position 1 sensor and reprogram the engine control module with a modified calibration, and initiate a Diesel Particulate Filter cleaning cycle. For vehicles previously serviced under recall 15594, dealers are to reprogram the engine control module with a modified calibration, and initiate a Diesel Particulate Filter cleaning cycle. Confirm status of recall 15594 following the instructions in the Warranty Information section.

(more…)

Product Emission Recall 13370 – Fuel Pump Pressure Regulator Replacement – 2014 Chevrolet Silverado & GMC Sierra

NHTSA ID Number: 10054993

Manufacturer Communication Number: RB-13370-A

 

Summary

GMC/CHEVROLET: DUE TO HAVING INCORRECT FUEL PUMP PRESSURE REGULATOR, AT TIME OF PRODUCTION, THE MALFUNCTION INDICATOR LAMP WILL ILLUMINATE, WILL HAVE HARD START CONDITION, THE ENGINE WILL STUMBLE AND/OR STALL OUT. MODEL 2014 SILVERADO 1500, SIERRA 1500.

(more…)

Product Emission Recall – Catalytic Converter Internal Damage – 2013-2014 Chevrolet Cruze & Chevrolet Sonic

NHTSA ID Number: 10143749

Manufacturer Communication Number: 16186 01

 

Summary

16186-01 – Emission Recall. On certain vehicles equipped with a 1.8L engine (RPO LWE), cracking of ceramic components internal to the catalytic converter may occur as a result of higher than anticipated exhaust temperatures. If this occurs, the catalytic converter low efficiency diagnostic will set and the malfunction indicator lamp will illuminate. Dealers are to reprogram the engine control module with calibrations that prevent higher than expected exhaust temperatures. (service procedure revised)

(more…)

Product Safety Recall 17036 Passenger Presence System – 2006-2010 Pontiac Solstice & 2007-2010 Saturn Sky

January 26, 2017 NHTSA CAMPAIGN NUMBER: 17V061000

Front Passenger Air bag may not Deploy

In the event of a crash, if the front passenger air bag does not deploy as intended, the front passenger has an increased risk of injury.

 

NHTSA Campaign Number: 17V061

Manufacturer General Motors LLC

Components AIR BAGS

Potential Number of Units Affected 91,007

 

Summary

General Motors LLC (GM) is recalling certain 2006-2010 Pontiac Solstice and 2007-2010 Saturn Sky vehicles. The Passenger Air Bag Suppression System (PPS) sensor may become bent or damaged within the front passenger seat, possibly disabling the front passenger air bag.

(more…)

Product Emission Recall – High Pressure Fuel Pump – 2010-2011 Chevrolet Equinox & GMC Terrain

NHTSA ID Number: 10119010

Manufacturer Communication Number: GCUS-3-702

 

Summary

43180 – Emission Recall. The engine mounted high pressure fuel pump may develop excessive wear on the plunger piston shaft and shaft seal. If this happens fuel can leak into the engine oil crankcase and result in the engine running rough and illumination of the malfunction indicator lamp. Dealers are to replace the high pressure fuel pump.

(more…)